Product ID:640 RUBBERIZED UNDERCOATING SPRAY
MSDS Date:11/14/1991
FSC:8030
NIIN:00N099149
MSDS Number: CCSRS

X LABORATORIES INC

440 DENNISTON CT
WHEELING, IL 60090
US

Emergency Phone: 800-942-5969

Info Phone: 708-459-5000

Preparer: P.A. ZOUBEK

Cage: XLABO

X LABORATORIES INC

WHEELING, IL 60090 US

Telephone: 800-942-5969

Cage: XLABO

SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (MINERAL

CAS: 64742-88-7

Fraction By Weight: 13%

OSHA PEL N/K

ACGIH TLV: N/K

METHANOL (SARA 313) (CERCLA)

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: 2.44%

OSHA PEL 200 PPM, S

ACGIH TLV: 200 PPM; 250 STEL, S

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PROPANE, 2-METHYL-; (ISOBUTANE)

CAS: 75-28-5

RTECS: TZ4300000

Fraction By Weight: 25-45%

OSHA PEL N/K

ACGIH TLV: N/K

CALCIUM CARBONATE

CAS: 1317-65-3

RTECS: EV9580000

Fraction By Weight: 16%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

ASPHALT; (NATURAL ASPHALT)

CAS: 8052-42-4

RTECS: CI9900000

Fraction By Weight: 7%

OSHA PEL N/K

ACGIH TLV: 5 MG/M3 (FUME)

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CONTACT W/EYES CAUSES
SEVERE IRRITATION, REDNESS, TEARING, BLURRED VISION. SKIN:
PROLONGED CONTACT W/SKIN MAY CAUSE MODERATE IRRITATION, REDNESS,
DRY SKIN. INHAL: EXCESSIVE BREATHING OF V APORS CAUSES NASAL &
RESPIRATORY IRRITATION, DIZZINESS, NAUSEA, HEADACHE, POSSIBLE
UNCONSCIOUSNESS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: INGEST: MAY CAUSE GASTROINTESTINAL
IRRITATION, NAUSEA, VOMITING & DIARRHEA. CHRONIC: OVEREXP TO
INGREDS IN THIS PRODUCT MAY CAUSE RESPIRATORY TRACT IRRITATION &
POSSIBLE LIVER & KIDNEY DAMAG E. ASPIRATION INTO LUNGS DUE TO
VOMITING MAY CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. TARGET
ORGANS:LIVER, KIDNEY.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES, LIFTING
EYELIDS OCCASIONALLY. SEE MD. SKIN: WASH WITH SOAP AND WATER.
INHALATION: REMOVE TO FRESH AIR. RESTORE NORMAL BREATHING. KEEP
PERSON WARM AND QU IET. GET MEDICAL ATTENTION. INGESTION: DO NOT
INDUCE VOMITING. CALL MD OR LOCAL POISON CONTROL CENTER IMMEDIATELY
FOR INSTRUCTIONS.

Flash Point Method:TCC
Flash Point:70.0F,21.1C
Lower Limits:1.6%
Upper Limits:10.6%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . WATER SPRAY MAY BE USED TO COOL FIRE-EXPOSED
CONTAINERS, PREVENTING PRESSURE BUILDUP & EXPLOSION.
Unusual Fire/Explosion Hazard:VAP ARE HVR/AIR & MAY TRAVEL A GREAT DIST
ALONG GROUND TO AN IGNIT SOURCE & FLASHBACK. DO NOT CUT/WELD ON OR
NEAR CNTNR AS PROD/PROD RESIDUE CAN IGNITE EXPLO.

Spill Release Procedures:SMALL SPILL: CONTAIN & COLLECT W/INERT ABSORB.
LARGE SPILL: ELIM ALL IGNIT SOURCES. VENT AREA. PERSONS NOT
INVOLVED IN CLEAN-UP & NOT WEARING PROT EQUIP SHOULD BE EVACUATED.
CONTAIN & COLLECT PROD W/I NERT ABSORB. PLACE IN CLSD CNTNRS
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:EMPTY CONTAINERS MAY RETAIN PRODUCT
RESIDUES WHICH MAY BE CONSIDERED HAZARDOUS. ALL PRECAUTIONS GIVEN
IN DATA SHEET MUST BE OBSERVED.
Other Precautions:USE WITH ADEQUATE VENTILATION. DO NOT PUNCTURE OR
INCINERATE CONTAINERS.

Respiratory Protection:NIOSH APPROVED AIR-PURIFYING ORGANIC VAPOR
RESPIRATOR IF CONCENTRATIONS ARE ABOVE PEL/TLV OR IF VAPORS ARE A
PROBLEM.
Ventilation:PROVIDE SUFFICIENT MECHANICAL VENTILATION TO MAINTAIN
EXPOSURE BELOW TLV.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
WEAR IMPERVIOUS CLOTHING & BOOTS TO PREVENT PRLNGD/RPTD SKIN
CONTACT.
Work Hygienic Practices:LAUNDER BEFORE REUSE.
Supplemental Safety and Health
SPILL PROC: NON-SPARKING TOOLS. PREVENT PRODUCT FROM ENTERING WATER
SUPPLY.

Boiling Pt:B.P. Text:>147F,>64C
Vapor Pres:21.5
Vapor Density:1.73
Spec Gravity:1.2 (H*2O=1)
Evaporation Rate & Reference:0.615 (BUAC=1)
Solubility in Water:EMULSION
Appearance and Odor:BLACK, VISCOUS LIQUID; PETROLEUM ODOR.
Percent Volatiles by Volume:72

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
VARIOUS HYDROCARBONS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.